Clean Station Works And How To Use - Clean Desk - Filtration And Separation Industry

Clean Taiwan has the advantage of easy to operate freely

, more comfortable, efficient, preparation time is short, the boot can be operated for more than 10 minutes, basically ready to use. In factory production, inoculation heavy workload, often for long hours of work required, Clean Desk is the ideal device. Clean Desk blast from the three-phase motor for power, power 145 ~ 260W or so, will air through the porous foam by the specially composed pieces stacked together a "super filter" the blowing out of the formation of a continuous dust-free Bacteria Clean air laminar flow, the so-called "efficiency particulate air", which removed more than 0.3 m dust, fungi and bacteria spores and so on. Clean the air flow rate of 24 ~ 30m/min, which are adequate to prevent possible harassment near the air pollution caused by such a flow will not prevent use of alcohol lamp or Bunsen burner burning on the disinfection of equipment and so on. Staff in such operations under sterile conditions, to maintain the transfer of sterile materials from contamination during inoculation. But what if a power cut halfway operation, exposed to unfiltered air contaminated material will be spared. At this time the work should be concluded quickly, and to mark the bottle, in the material, such as in the proliferation phase, which will no longer be used as a proliferation of roots into the culture. As for the general production of materials, as extremely rich can also be discarded. Such as in the rooting process, can be left to later planting.

Clean power station to use more three-phase four-wire system, which includes a zero line, connected the exterior, should be connected firmly to the ground line, the other three lines are the phase line, the working voltage is 380V. Third-line access to the circuit in a certain order, such as the thread are wrong, the wind opportunity to reverse, when the sound is normal or slightly abnormal, Clean Desk positive no wind? Can use an alcohol lamp flame observation of movement, not long-trial, should be timely cut off the power, as long as any of the two phases will be to exchange positions were followed by the thread, you can solve. Three-phase line, such as access only to two-phase or three phase, there is a similar connection is bad, the machine sounds very normal, careful inspection should be immediately cut off the power, otherwise they will burn motor. These common sense should start using ultra-clean platform to explain to the staff when clear, remove the cause of the accident and the loss should not be.

Clean Desk at the back or front air inlet below the metal mesh cover has one piece of ordinary foam or woven to block large particles of dust, should always check, washable, foam aging are found, must be promptly replacement. In addition to outside air inlet and, if leakage pores, blocking should be strict, such as adhesive plasters, cotton plugs, glue paper and paste. Table inside the front cover of metal mesh filter is super, super filter may be replaced, as a result of use in a long time, blocking dust, wind speed decreases, can not guarantee aseptic operation, we can put a new one.

The length of life of ultra-clean station and the cleanliness of the air. Clean Desk in temperate regions may be in the general laboratory use, but in tropical or subtropical regions, because the atmosphere contains high levels of pollen, or dust in the area, ultra-clean units are advised to double-doors on a good indoor use. Clean any case, Taiwan should not be facing into the wind shield doors or windows open, so as not to affect the filter life.

Sterile room should be on a regular basis with 70% alcohol or 0.5% phenol spraying dust and disinfected with 2% Bromogeramine wiped countertops and appliances? 70% alcohol can also use a small amount of formalin plus 40% formaldehyde airtight fumigation of potassium permanganate on a regular basis, with the ultraviolet sterilization lamps? more than 15 minutes, so every time you open a means of disinfection and sterilization, sterile rooms in order to keep a high level of aseptic state. Vaccination should also be equipped with a UV box inside lights, turn on the lights 15 minutes before using radiation sterilization, irradiation, but not between those who still carry bacteria. Open longer in the UV light, may stimulate oxygen in the air of ozone molecules enter into synthesis, the gas composition has a strong bactericidal effect, can not shine directly on the corner of ultraviolet sterilization effect produced. As the ozone unhealthy, enter operations should be preceded by off ultraviolet light, after more than 10 minutes off can enter.

Also lifting bench in the Super Clean UV lights, but it should be installed outside in the light shade, and stagger the lights arranged in parallel, so that work does not preclude lighting. If we ultraviolet light into light shade? Glass inside, which is useless, because the UV rays can penetrate glass, it is a quartz glass tube, not made of silicate glass.

Vaccination room be brief, and the room where the work not directly related to goods can not be placed in order to facilitate to maintain sterile conditions.

by: gaga

POST COMMENT

Few Facts on Partial Knee Replacement and Rehab Awaken the Giant Within – And Be All That You Can Be Contract Deals - Gives Rise to Fresh and Enhanced Ideas Which Slippers Offer The Best Comfort And Functionality Wear Casio Calculator Watch in All Occasions and Celebrations Driving On The Ice And Snow Eye-catching And Protective Tarpaulins Disabled Individuals And Those With Pre-existing Conditions Will Be Getting A Break In 2014 How to hide files and folders on your Mac Extra Strength And Durable Tarpaulins Organic Pest Curb And Its Pros Common Problems And Solution When Wearing Cpap Mask Dumbwaiter - Adds Elegance and Convenience